Volvo

Volvo Engine D11L (Tier 4) Fault Code: SID 6 FMI 5 Injector #6 CONTROL UNIT:Engine ECU DETECTION CONDITIONS:The engine control unit (E-ECU) registers current too low. SYMPTOM:1. Low power.2. Engine runs rough/ varying engine speed.3. 3- or 5-cylinder operation. POSSIBLE CAUSES:1. Short circuit to lower voltage on injector’s low voltage side.2. Short-circuit to higher- or lower-voltage on injector’s high voltage side.3. Open circuit on injector’s high voltage side. Volvo Engine D11L (Tier 4) Fault Code: SID 6 FMI 3 Injector #6 Volvo Engine D11L (Tier 4) Fault Code: SID 5 FMI 7 Injector #5 Volvo Engine D11L (Tier 4) Fault...

Volvo Engine D11L (Tier 4) Fault Code: SID 6 FMI 7 Injector #6 CONTROL UNIT:Engine ECU DETECTION CONDITIONS:The engine control unit (E-ECU) registers cylinder balancing data out of limit. SYMPTOM:1. Uneven engine running at idle speed.2. Injector in question is shut off. POSSIBLE CAUSES:1. Defect injector.2. Bad compression.3. Leakage between injector sleeve and cylinder head.4. Leakage between injector sleeve and injector. Volvo Engine D11L (Tier 4) Fault Code: SID 6 FMI 5 Injector #6 Volvo Engine D11L (Tier 4) Fault Code: SID 6 FMI 3 Injector #6 Volvo Engine D11L (Tier 4) Fault Code: SID 5 FMI 7 Injector #5...

Volvo Engine D11L (Tier 4) Fault Code: SID 70 FMI 3 Air Inlet Heater Driver #1 CONTROL UNIT:Engine ECU DETECTION CONDITIONS:The engine control unit (E-ECU) registers that the voltage is equal to Ubat. SYMPTOM:1. Relay may be continuously activated.2. High cooling fan speed for charge-air cooling due to high inlet temperature. POSSIBLE CAUSES:Signal line short-circuited to Ubat. Volvo Engine D11L (Tier 4) Fault Code: SID 39 FMI 10 Engine Starter Motor Relay Volvo Engine D11L (Tier 4) Fault Code: SID 39 FMI 7 Engine Starter Motor Relay Volvo Engine D11L (Tier 4) Fault Code: SID 39 FMI 5 Engine Starter...

Volvo Engine D11L (Tier 4) Fault Code: SID 70 FMI 4 Air Inlet Heater Driver #1 CONTROL UNIT:Engine ECU DETECTION CONDITIONS:The engine control unit (E-ECU) registers that the voltage is below 22 V(0.91 x Ubat). SYMPTOM:1. Preheating not functioning.2. White smoke during cold starts.3. Difficult to start in extreme cold. POSSIBLE CAUSES:1. Signal line short-circuited to frame ground.2. Defective relay. Volvo Engine D11L (Tier 4) Fault Code: SID 70 FMI 3 Air Inlet Heater Driver #1 Volvo Engine D11L (Tier 4) Fault Code: SID 39 FMI 10 Engine Starter Motor Relay Volvo Engine D11L (Tier 4) Fault Code: SID 39...

Volvo Engine D11L (Tier 4) Fault Code: SID 70 FMI 5 Air Inlet Heater Driver #1 CONTROL UNIT:Engine ECU DETECTION CONDITIONS:The engine control unit (E-ECU) registers that the voltage is between 7 V and 22 V ( 0.30 x Ubat and 0.91 x Ubat). SYMPTOM:1. Preheating not functioning.2. Difficult to start in extreme cold. POSSIBLE CAUSES:1. Defective fuse on feed cable.2. Open circuit in preheating coil.3. Open circuit in cable harness. Volvo Engine D11L (Tier 4) Fault Code: SID 70 FMI 4 Air Inlet Heater Driver #1 Volvo Engine D11L (Tier 4) Fault Code: SID 70 FMI 3 Air Inlet...