Volvo

Volvo Engine D11L (Tier 4) Fault Code: P02E012 PID: PSID 7 FMI: 3 Diesel Intake Air Flow Control – Circuit Short To Battery CONTROL UNIT:Engine ECU FAILURE EVENT:Short circuit to higher voltage has been detected. SYMPTOM:None CONDITIONS:None INHIBITING THE DTC:U300001 / MID128 PID158 FMI5 / EF2104-5 POSSIBLE CAUSES:1. Damaged wire harness or connector.2. Defective inlet throttle motor. Volvo Engine D11L (Tier 4) Fault Code: EF3602 PID: FMI: 9 Critical Bus Communication Failure Volvo Engine D11L (Tier 4) Fault Code: EF3602 PID: FMI: 9 Critical Bus Communication Failure Volvo Engine D11L (Tier 4) Fault Code: EF3601 PID: FMI: 9 Performance Loss...

Volvo Engine D11L (Tier 4) Fault Code: P02E699 PID: 51 FMI: 7 Diesel Intake Air Flow Position Sensor – Exceeded Learning Limit CONTROL UNIT:Engine ECU FAILURE EVENT:The inlet throttle calibration cannot be performed. SYMPTOM:1. Engine has low power.2. Engine runs rough. CONDITIONS:Calibration requested INHIBITING THE DTC:1. P009501 / MID128 PID105 FMI12 / SE2507-122. P009511 / MID128 PID105 FMI4 / SE2507-43. P009513 / MID128 PID105 FMI5 / SE2507-54. P02E011 / MID128 PSID7 FMI4 / MO2503-45. P02E012 / MID128 PSID7 FMI3 / MO2503-36. P02E013 / MID128 PSID7 FMI5 / MO2503-57. P02E612 / MID128 PID51 FMI3 / MO2503-38. P02E613 / MID128 PID51 FMI5...

Volvo Engine D11L (Tier 4) Fault Code: P04009C PID: PPID 35 FMI: 1 Exhaust Gas Recirculation “A” Flow – Low/Insufficient Flow CONTROL UNIT:Engine ECU FAILURE EVENT:Temperature difference too low in inlet manifold when activating EGR valve (<3?C / <5?F). SYMPTOM: 1. Low power because of engine derate. 2. Display message: SCR system failure, derate will occur soon. CONDITIONS: 1. Ambient air pressure between 75 kPa (10.9 psi) and 200 kPa (29.0 psi). 2. Engine coolant temperature between 65?C (149?F) and 100?C (212?F). 3. Engine Speed between 400 rpm and 2000 rpm. 4. Engine torque between 50 Nm and 3000 Nm....

Volvo Engine D11L (Tier 4) Fault Code: P040311 PID: SID 146 FMI: 3 EGR “A” Control – Circuit Short To Ground CONTROL UNIT:Engine ECU FAILURE EVENT:Short circuit to lower voltage has been detected. SYMPTOM:1. Low power because of engine derate.2. Display message: SCR system failure, derate will occur soon. CONDITIONS:None INHIBITING THE DTC:U300001 / MID128 PID158 FMI5 / EF2104-5 POSSIBLE CAUSES:1. Defective EGR valve.2. Damaged wire harness or connector. Volvo Engine D11L (Tier 4) Fault Code: P029900 PID: PSID 98 FMI: 1 Turbocharger/Supercharger Underboost – No Sub Type Information Volvo Engine D11L (Tier 4) Fault Code: P012800 PID: PSID 109...

Volvo Engine D11L (Tier 4) Fault Code: P047001 PID: 131 FMI: 12 Exhaust Pressure Sensor “A” – General Electrical Failure CONTROL UNIT:Engine ECU FAILURE EVENT:Value out of range has been detected. Voltage between 4.79 – 4.85 V. Or voltage between 0.15 – 0.21 V. SYMPTOM:Decreased engine brake power. CONDITIONS:None INHIBITING THE DTC:1. P06B316 / MID128 SID211 FMI4 / EF2102-42. P06B317 / MID128 SID211 FMI3 / EF2102-33. U300001 / MID128 PID158 FMI5 / EF2104-5 POSSIBLE CAUSES:1. Damaged wire harness or connector.2. Defective exhaust gas pressure sensor after turbocharger. Volvo Engine D11L (Tier 4) Fault Code: P040311 PID: SID 146 FMI: 3...