Detroit Diesel

DESCRIPTION:This code sets when the Intake Throttle Valve position has A 15% deviation from the position commanded by the Motor Control Module (MCM) when the engine coolant temperature is above 60°C (140°F) MONITORED PARAMETER:Intake Throttle Valve (ITV) TYPICAL ENABLING CONDITIONS:Coolant temperature is greater than 60°C (140°F). MONITOR SEQUENCE:None EXECUTION FREQUENCY:Continuous when enabling conditions met. TYPICAL DURATION:Five seconds DASH LAMPS:1. MIL2. CEL ENGINE REACTION:10% Derate VERIFICATION:Engine rpm = 600 rpm or higher. POSSIBLE CAUSES:1. Faulty ITV motor.2. Faulty ITV position sensor.3. Sticking ITV. PROBABLE CAUSES:1. Air throttle valve harness.2. ITV harness connector.3. Intake throttle valve failure.4. Cold temperatures may falsely cause...

DESCRIPTION:This fault code sets when there is a short to voltage on the intake throttle valve circuit. MONITORED PARAMETER:Intake air throttle TYPICAL ENABLING CONDITIONS:Key on MONITOR SEQUENCE:None EXECUTION FREQUENCY:Always enabled TYPICAL DURATION:2 seconds DASH LAMPS:1. MIL2. CEL ENGINE REACTION:Derate 10% VERIFICATION:Engine Idle: One minute. PROBABLE CAUSES:1. Air throttle valve harness.2. ITV harness connector.3. Intake throttle valve failure.4. Cold temperatures may falsely cause this code to appear.5. Intake throttle valve sensor. Detroit DD13 EPA10 (2010-13) Fault Code: SPN 51 FMI 2 (MCM) Intake Throttle Position Deviation Error Detroit DD15 EPA10 (2010-13) Fault Code: SPN 524292 FMI 1 (MCM, ACM) This Diagnostic...

DESCRIPTION:This fault code sets when there is an open on the intake throttle valve circuit. MONITORED PARAMETER:Intake Air Throttle TYPICAL ENABLING CONDITIONS:Key on MONITOR SEQUENCE:None EXECUTION FREQUENCY:Always enabled TYPICAL DURATION:2 seconds DASH LAMPS:1. MIL2. CEL ENGINE REACTION:Derate 10% VERIFICATION:Engine Idle: One minute. PROBABLE CAUSES:1. Air throttle valve harness.2. ITV harness connector.3. Intake throttle valve failure.4. Cold temperatures may falsely cause this code to appear.5. Intake throttle valve sensor. Detroit DD13 EPA10 (2010-13) Fault Code: SPN 51 FMI 3 (MCM) Intake Throttle Valve Circuit Failed High Detroit DD13 EPA10 (2010-13) Fault Code: SPN 51 FMI 2 (MCM) Intake Throttle Position Deviation...

NOTE: Please see the step by step troubleshooting procedures for this specific code. PROBABLE CAUSES:1. Engine computer(s) have been programmed recently. Clear the codes and release the vehicle.2. Turn key off then back on again and re-check. If still active, use code 625-9 to troubleshoot. Detroit DD13 EPA10 (2010-13) Fault Code: SPN 411 FMI 13 (MCM) EGR Delta Pressure Sensor Out of Calibration Detroit DD13 EPA10 (2010-13) Fault Code: SPN 411 FMI 4 (MCM) EGR Delta Pressure Sensor Circuit Failed Low Detroit DD13 EPA10 (2010-13) Fault Code: SPN 411 FMI 4 (MCM) Exhaust Gas Recirculation Delta P Sensor Short to...

NOTE: Please see the step by step troubleshooting procedures for this specific code. PROBABLE CAUSES:1. If any engine ECM has been recently programmed, ensure the parameters are correct.2. Turn key off, wait 5 minutes, turn back on. If code doesn’t go active, clear code and release truck to customer.3. Follow 625-9 for troubleshooting. Detroit DD13 EPA10 (2010-13) Fault Code: SPN 65279 FMI 16 (MCM) Water-In-Fuel (WIF) Ignored-Shutdown Detroit DD13 EPA10 (2010-13) Fault Code: SPN 65279 FMI 15 (MCM) Water-In-Fuel (WIF) Ignored-Derate Detroit DD13 EPA10 (2010-13) Fault Code: SPN 5444 FMI 1 (MCM) Engine Crankcase Breather Oil Separator Speed Too Low...