Detroit Diesel

DESCRIPTION:Injector needle control valve cylinder 4, 5, 6 shorted to battery. MONITORED PARAMETER:Injector needle control valve cylinder 4, 5, 6. TYPICAL ENABLING CONDITIONS:Engine rpm = idle or higher. MONITOR SEQUENCE:None EXECUTION FREQUENCY:Continuous when enabling conditions met. TYPICAL DURATION:Two seconds DASH LAMPS:1. MIL2. CEL ENGINE REACTION:Derate 25% VERIFICATION:Engine Idle: One minute. PROBABLE CAUSES:1. Short to power between front fuel injector harness (14-pin connector) and the ECM (120-pin connector).2. Under valve cover fuel injector harness. Detroit DD13 EPA10 (2010-13) Fault Code: SPN 2797 FMI 4 (MCM) Fuel Injector Needle Control Valve Cylinder 1, 2, 3 Shorted to Ground Detroit DD13 EPA10 (2010-13)...

DESCRIPTION:Injector needle control valve cylinder 4, 5, 6, shorted to ground. MONITORED PARAMETER:Injector needle control valve cylinder 4, 5, 6. TYPICAL ENABLING CONDITIONS:Engine rpm = Idle or higher. MONITOR SEQUENCE:None EXECUTION FREQUENCY:Continuous when enabling conditions met. TYPICAL DURATION:Two seconds DASH LAMPS:1. MIL2. CEL ENGINE REACTION:Derate 25% VERIFICATION:Engine Idle: One minute. PROBABLE CAUSES:1. Injector 4, 5, or 6.2. Short to ground between pin 25 of the 120-pin ECM connection and pin 1 of the front fuel injector harness (14-pin) connector.3. Failed MCM (Engine ECM). Detroit DD13 EPA10 (2010-13) Fault Code: SPN 2798 FMI 3 (MCM) Injector Needle Control Valve Cylinder 4,...

NOTE: Fault will set during transmission module reprogramming. If fault occurs while programming, clear code and release vehicle. NOTE: If any battery voltage codes present, first those first. If code 625-9 active, fix that before proceeding as well. PROBABLE CAUSES:1. CPC recently programmed incorrectly.2. Another computer on the truck is the cause of the problems (ABS, Transmission, etc…). Detroit DD13 EPA10 (2010-13) Fault Code: SPN 2798 FMI 4 (MCM) Injector Needle Control Valve Cylinder 4, 5, 6 Shorted to Ground Detroit DD13 EPA10 (2010-13) Fault Code: SPN 2798 FMI 3 (MCM) Injector Needle Control Valve Cylinder 4, 5, 6 Shorted...

DESCRIPTION:Diesel exhaust fluid (DEF) tank temperature sensor circuit failed high. MONITORED PARAMETER:DEF tank temperature sensor. TYPICAL ENABLING CONDITIONS:Always enabled MONITOR SEQUENCE:None EXECUTION FREQUENCY:Always enabled TYPICAL DURATION:Two seconds DASH LAMPS:1. MIL2. CEL ENGINE REACTION:25% Derate. After four hours, engine will be idled after ignition key cycle. VERIFICATION:Engine Idle: one minute. PROBABLE CAUSES:1. DEF tank level/temperature sensor harness/connector.2. DEF tank level/temperature sensor. Detroit DD13 EPA10 (2010-13) Fault Code: SPN 2900 FMI 9 (CPC) ETC7 Message is Missing Detroit DD13 EPA10 (2010-13) Fault Code: SPN 2798 FMI 4 (MCM) Injector Needle Control Valve Cylinder 4, 5, 6 Shorted to Ground Detroit DD13 EPA10...

DESCRIPTION:Diesel exhaust fluid (DEF) tank temperature sensor circuit failed low. MONITORED PARAMETER:DEF tank temperature sensor. TYPICAL ENABLING CONDITIONS:Always enabled MONITOR SEQUENCE:None EXECUTION FREQUENCY:Always enabled TYPICAL DURATION:Two seconds DASH LAMPS:1. MIL2. CEL ENGINE REACTION:25% Derate. After Four hours, engine will be idled after ignition key cycle. VERIFICATION:Engine Idle: One minute. PROBABLE CAUSES:1. DEF tank level/temperature sensor harness/connector.2. DEF tank level/temperature sensor. Detroit DD13 EPA10 (2010-13) Fault Code: SPN 3031 FMI 3 (ACM) Diesel Exhaust Fluid Tank Temperature Sensor Circuit Failed High Detroit DD13 EPA10 (2010-13) Fault Code: SPN 2900 FMI 9 (CPC) ETC7 Message is Missing Detroit DD13 EPA10 (2010-13) Fault...