Volvo

Volvo Engine D12D AE E3 (Tier 3) Fault Code: SID6 FMI 7 Injector #6 DETECTION CONDITIONS:The engine control unit (E-ECU) registers:1. Injector activated.2. Cylinder balancing data above limit. SYMPTOM:1. Low power.2. Engine runs rough/varying engine speed.3. Abnormal sound.4. Injector in question is shut off. POSSIBLE CAUSES:1. Defect injector.2. Poor compression.3. Air in fuel at injector. Volvo Engine D12D AE E3 (Tier 3) Fault Code: SID6 FMI 5 Injector #6 Volvo Engine D12D AE E3 (Tier 3) Fault Code: SID6 FMI 3 Injector #6 Volvo Engine D12D AE E3 (Tier 3) Fault Code: SID5 FMI 7 Injector #5 Volvo Engine D12D...

Volvo Engine D12D AE E3 (Tier 3) Fault Code: SID70 FMI 3 Air Inlet Heater Driver #1 DETECTION CONDITIONS:The engine control unit (E-ECU) registers:1. Relay for preheating coil not activated.2. That the voltage is above 0.65xUbat. (EB7) SYMPTOM:1. Relay may be continuously activated.2. High cooling fan speed for charge-air cooling due to high inlet temperature.3. High current consumption.4. Poor battery. POSSIBLE CAUSES:1. Signal line short-circuited to Ubat. (EB7)2. Relay continuously activated. Volvo Engine D12D AE E3 (Tier 3) Fault Code: SID39 FMI 10 Engine Starter Motor Relay Volvo Engine D12D AE E3 (Tier 3) Fault Code: SID39 FMI 5 Engine...

Volvo Engine D12D AE E3 (Tier 3) Fault Code: SID70 FMI 4 Air Inlet Heater Driver #1 DETECTION CONDITIONS:The engine control unit (E-ECU) registers:1. Drive step for relay for preheating coil activated.2. Signal line short-circuited to frame ground. (EB7) SYMPTOM:1. Preheating not functioning.2. White smoke during cold starts.3. Difficult to start in extreme cold. POSSIBLE CAUSES:1. Signal line short-circuited to frame ground. (EB7)2. Defective relay. Volvo Engine D12D AE E3 (Tier 3) Fault Code: SID70 FMI 3 Air Inlet Heater Driver #1 Volvo Engine D12D AE E3 (Tier 3) Fault Code: SID39 FMI 10 Engine Starter Motor Relay Volvo Engine...

Volvo Engine D12D AE E3 (Tier 3) Fault Code: SID70 FMI 5 Air Inlet Heater Driver #1 DETECTION CONDITIONS:The engine control unit (E-ECU) registers current too low. (EB7) SYMPTOM:1. Preheating not functioning.2. Difficult to start in extreme cold. POSSIBLE CAUSES:1. Defective fuse on feed cable.2. Open circuit in preheating coil.3. Open circuit in cable harness. Volvo Engine D12D AE E3 (Tier 3) Fault Code: SID70 FMI 4 Air Inlet Heater Driver #1 Volvo Engine D12D AE E3 (Tier 3) Fault Code: SID70 FMI 3 Air Inlet Heater Driver #1 Volvo Engine D12D AE E3 (Tier 3) Fault Code: SID39 FMI...

Volvo Engine D11L (Tier 4) Fault Code: EF3601 PID: FMI: 9 Performance Loss Bus Communication Failure SHOP TALK CONTAINS CRITERIA FOR THE FOLLOWING:1. Instrument Control Unit (HMIM)2. Vehicle Control Unit (V-ECU)3. Vehicle Control Unit 2 (V2-ECU) INSTRUMENT CONTROL UNIT (HMIM)DETECTION CONDITIONS:The Instrument Control Unit (HMIM) registers that bus communication is missing with E-ECU on CAN1/J1939. SYMPTOM:None POSSIBLE CAUSES:Open circuit on bus communication (cable harness) (SAE J1939 CAN1). VEHICLE CONTROL UNIT (V-ECU)DETECTION CONDITIONS:The Vehicle Control Unit (V-ECU) registers that bus communication is missing with ECC on J1708/J1587. SYMPTOM:The climate control unit does not work correctly. POSSIBLE CAUSES:1. Ongoing diagnostic software operation:...