Detroit DD16 EPA07 (2007-09) Fault Code: SPN 164 FMI 0 (MCM) Quantity Control Valve High Side Driver Error

DESCRIPTION:
Quantity control valve (high side).

MONITORED PARAMETER:
Quantity control valve (QCV).

TYPICAL ENABLING CONDITIONS:
Always enabled

MONITOR SEQUENCE:
None

EXECUTION FREQUENCY:
Continuous when enabling conditions met.

TYPICAL DURATION:
2 seconds

DASH LAMPS:
1. MIL
2. CEL

ENGINE REACTION:
Derate 25%

VERIFICATION:
Engine idle: 1 minute.

PROBABLE CAUSES:
1. ECM pin 1 shorted to ground.
2. Quantity control valve failure.
3. Quantity control valve harness/connector.

Detroit DD16 EPA07 (2007-09) Fault Code: SPN 158 FMI 2 (MCM, CPC ) Ignition Switch Not Plausible

Detroit DD16 EPA07 (2007-09) Fault Code: SPN 157 FMI 16 (MCM) Fuel Rail Pressure Too Low

Detroit DD16 EPA07 (2007-09) Fault Code: SPN 157 FMI 2 (MCM) Erratic Fuel Rail Pressure Sensor Signal

Detroit DD16 EPA07 (2007-09) Fault Code: SPN 157 FMI 1 (MCM) Fault of the Fuel Rail Pressure Sensor, Wiring, or Quantity Control Valve

Detroit DD16 EPA07 (2007-09) Fault Code: SPN 132 FMI 1 (MCM) Air Mass Flow Too Low

Detroit DD16 EPA07 (2007-09) Fault Code: SPN 111 FMI 4 (CPC) Coolant Level Circuit Failed Low

Language