Volvo

Volvo Engine D11L (Tier 4) Fault Code: SID 2 FMI 7 Injector #2 CONTROL UNIT:Engine ECU DETECTION CONDITIONS:The engine control unit (E-ECU) registers cylinder balancing data out of limit. SYMPTOM:1. Uneven engine running at idle speed.2. Injector in question is shut off. POSSIBLE CAUSES:1. Defect injector.2. Bad compression.3. Leakage between injector sleeve and cylinder head.4. Leakage between injector sleeve and injector. Volvo Engine D11L (Tier 4) Fault Code: SID 2 FMI 5 Injector #2 Volvo Engine D11L (Tier 4) Fault Code: SID 2 FMI 3 Injector #2 Volvo Engine D11L (Tier 4) Fault Code: SID 1 FMI 7 Injector #1...

Volvo Engine D11L (Tier 4) Fault Code: SID 21 FMI 2 Engine Position CONTROL UNIT:Engine ECU DETECTION CONDITIONS:The engine control unit (E-ECU) registers mechanical fault. SYMPTOM:Increased fuel consumption. POSSIBLE CAUSES:Engine transmission not correct; bad correlation between camshaft and crankshaft. Volvo Engine D11L (Tier 4) Fault Code: SID 6 FMI 7 Injector #6 Volvo Engine D11L (Tier 4) Fault Code: SID 6 FMI 5 Injector #6 Volvo Engine D11L (Tier 4) Fault Code: SID 6 FMI 3 Injector #6 Volvo Engine D11L (Tier 4) Fault Code: SID 5 FMI 7 Injector #5 Volvo Engine D11L (Tier 4) Fault Code: SID 5...

Volvo Engine D11L (Tier 4) Fault Code: SID 21 FMI 3 Engine Position CONTROL UNIT:Engine ECU DETECTION CONDITIONS:The engine control unit (E-ECU) registers that the signal from the speed sensor is missing. SYMPTOM:1. Engine is difficult to start, only after a long time of cranking.2. Loss of power. POSSIBLE CAUSES:1. Loose connection.2. Incorrectly installed sensor.3. Defective sensor.4. Short circuit to voltage.5. Open circuit. Volvo Engine D11L (Tier 4) Fault Code: SID 21 FMI 2 Engine Position Volvo Engine D11L (Tier 4) Fault Code: SID 6 FMI 7 Injector #6 Volvo Engine D11L (Tier 4) Fault Code: SID 6 FMI 5...

Volvo Engine D11L (Tier 4) Fault Code: SID 21 FMI 8 Engine Position CONTROL UNIT:Engine ECU DETECTION CONDITIONS:The engine control unit (E-ECU) registers that frequency of the signal from the sensor is abnormal. SYMPTOM:1. Difficult to start at next start attempt (no symptom if error code is generated when engine is running).2. Loss of power. POSSIBLE CAUSES:1. Electric interference on speed signal.2. Poor insulation or defective cable.3. Incorrectly installed sensor (incorrect distance to sensor gear).4. Defective sensor.5. Defective sensor gear. Volvo Engine D11L (Tier 4) Fault Code: SID 21 FMI 3 Engine Position Volvo Engine D11L (Tier 4) Fault Code:...

Volvo Engine D11L (Tier 4) Fault Code: SID 211 FMI 3 Sensor Supply Voltage #2 (+5V DC) CONTROL UNIT:Engine ECU DETECTION CONDITIONS:The engine control unit (E-ECU) registers that the voltage is above 5.505 V. SYMPTOM:Incorrect values from engine’s sensors generated. POSSIBLE CAUSES:Short circuit to higher voltage. Volvo Engine D11L (Tier 4) Fault Code: SID 70 FMI 5 Air Inlet Heater Driver #1 Volvo Engine D11L (Tier 4) Fault Code: SID 70 FMI 4 Air Inlet Heater Driver #1 Volvo Engine D11L (Tier 4) Fault Code: SID 70 FMI 3 Air Inlet Heater Driver #1 Volvo Engine D11L (Tier 4) Fault...