Volvo

Fault Condition: PPID 35 will set with FMI 5 if the EGR ECU detects an open in the exhaust gas temperature probe circuit. Possible repairs: Turn the ignition key OFF first. 1) If the FMI is 3 (voltage high/open) or 5 (current low/open), replace the EGR Mass Flow Sensor assembly and retest the system.2)Remove connector A from the EGR ECU. Turn the ignition switch ON. Check for battery voltage (+12V) between pin 2 of EGR ECU connector A and a known good ground. If battery voltage is NOT present, a problem exists between EGR ECU connector A pin 2 and...

Fault Condition: PPID 35 will set with FMI 9 if the EGR ECU signal is missing on the J1939 serial data lines. Possible repairs: Turn the ignition key OFF first. 1) Remove connector A from the EGR ECU. Turn the ignition switch ON. Check for battery voltage (+12V) between pin 2 of EGR ECU connector A and a known good ground. If battery voltage is NOT present, a problem exists between EGR ECU connector A pin 2 and the power supply from the EMS Relay. Inspect the EGR ECU and EMS Relay connectors for damaged or loose pins. If the...

Fault Condition: Code PPID 55 will set when there is an internal error within the Engine Management System (EMS) Module. The EMS Module must be replaced if this fault occurs. Volvo All Engines (2004 Emissions) Fault Code: PPID 55 FMI 5 ECU Temperature Volvo All Engines (2004 Emissions) Fault Code: PID 252 FMI 9 Date Data Failure Volvo All Engines (2004 Emissions) Fault Code: SID 253 FMI 12 Dataset Memory Volvo All Engines (2004 Emissions) Fault Code: PID 85 FMI 9 Cruise Control Status Volvo All Engines (2004 Emissions) Fault Code: PID 153 FMI 0 Crankcase Pressure Sensor Volvo All...

Fault Condition: Code PPID 55 will set when there is an internal error within the Engine Management System (EMS) Module. The EMS Module must be replaced if this fault occurs. Volvo All Engines (2004 Emissions) Fault Code: PID 252 FMI 9 Date Data Failure Volvo All Engines (2004 Emissions) Fault Code: SID 253 FMI 12 Dataset Memory Volvo All Engines (2004 Emissions) Fault Code: PID 85 FMI 9 Cruise Control Status Volvo All Engines (2004 Emissions) Fault Code: PID 153 FMI 0 Crankcase Pressure Sensor Volvo All Engines (2004 Emissions) Fault Code: PID 153 FMI 3 Crankcase Pressure Sensor Volvo...

Fault Condition: The Engine Retarder Percent code will set when the Engine Management System (EMS) Module has lost the Engine Retarder Percent signal from the Vehicle Electronic Control Unit (VECU). Possible repairs: 1) Verify that code PPID 86 is set. If code PPID 86 is not set, wiggle the harness and connectors to try to set the code. Visually inspect the VECU connectors and wires for poor connections.2) Turn the ignition key OFF and connect a diagnostic computer. Turn the ignition key ON. Use the diagnostic computer to attempt to communicate with the Vehicle Electronic Control Unit (VECU).If communication can...