Volvo

Volvo Engine D11L (Tier 4) Fault Code: SID 211 FMI 4 Sensor Supply Voltage #2 (+5V DC) CONTROL UNIT:Engine ECU DETECTION CONDITIONS:The engine control unit (E-ECU) registers that the voltage is below 4.495 V. SYMPTOM:Incorrect values from engine’s sensors generated. POSSIBLE CAUSES:1. Short circuit to lower voltage.2. Defective sensor. Volvo Engine D11L (Tier 4) Fault Code: SID 211 FMI 3 Sensor Supply Voltage #2 (+5V DC) Volvo Engine D11L (Tier 4) Fault Code: SID 70 FMI 5 Air Inlet Heater Driver #1 Volvo Engine D11L (Tier 4) Fault Code: SID 70 FMI 4 Air Inlet Heater Driver #1 Volvo Engine...

Volvo Engine D11L (Tier 4) Fault Code: SID 22 FMI 2 Timing Sensor, Crank CONTROL UNIT:Engine ECU DETECTION CONDITIONS:The engine control unit (E-ECU) registers intermittent signal loss or signal error. SYMPTOM:1. Engine runs rough/ varying engine speed.2. Misfiring.3. Engine is difficult to start, only after a long time of cranking.4. Fuel consumption higher than normal. POSSIBLE CAUSES:1. Electric interference on speed signal.2. Loose connection.3. Poor insulation or defective cable.4. Incorrectly installed sensor.5. Defective sensor.6. Damaged gear teeth on flywheel. Volvo Engine D11L (Tier 4) Fault Code: SID 21 FMI 8 Engine Position Volvo Engine D11L (Tier 4) Fault Code: SID...

Volvo Engine D11L (Tier 4) Fault Code: SID 22 FMI 3 Timing Sensor, Crank CONTROL UNIT:Engine ECU DETECTION CONDITIONS:The engine control unit (E-ECU) registers that the signal from the speed sensor is missing. SYMPTOM:1. Fuel consumption higher than normal.2. Engine runs rough/ varying engine speed.3. Misfiring. POSSIBLE CAUSES:1. Loose connection.2. Incorrectly installed sensor.3. Defective sensor.4. Short circuit to voltage.5. Open circuit. Volvo Engine D11L (Tier 4) Fault Code: SID 22 FMI 2 Timing Sensor, Crank Volvo Engine D11L (Tier 4) Fault Code: SID 21 FMI 8 Engine Position Volvo Engine D11L (Tier 4) Fault Code: SID 21 FMI 3 Engine...

Volvo Engine D11L (Tier 4) Fault Code: SID 22 FMI 8 Timing Sensor, Crank CONTROL UNIT:Engine ECU DETECTION CONDITIONS:The engine control unit (E-ECU) registers abnormal frequency of signal from the speed sensor. SYMPTOM:1. Fuel consumption higher than normal.2. Engine runs rough/ varying engine speed.3. Misfiring. POSSIBLE CAUSES:1. Electric interference on speed signal.2. Incorrectly installed sensor (incorrect distance to sensor gear).3. Defective sensor.4. Damaged gear teeth on flywheel. Volvo Engine D11L (Tier 4) Fault Code: SID 22 FMI 3 Timing Sensor, Crank Volvo Engine D11L (Tier 4) Fault Code: SID 22 FMI 2 Timing Sensor, Crank Volvo Engine D11L (Tier 4)...

Volvo Engine D11L (Tier 4) Fault Code: SID 231 FMI 2 SAE J1939 Data Link CONTROL UNIT:Engine ECU DETECTION CONDITIONS:No messages arriving on the control link (SAE Fault mode J1939). SYMPTOM:1. Starter motor cannot be activated.2. The machine does not go into gear.3. Engine brake not functioning. POSSIBLE CAUSES:1. Short-circuit to voltage on control link (SAE J1939).2. Short-circuit to frame ground on control link (SAE J1939).3. Leads in control link (SAE J1939) short-circuited to each other. Volvo Engine D11L (Tier 4) Fault Code: SID 211 FMI 4 Sensor Supply Voltage #2 (+5V DC) Volvo Engine D11L (Tier 4) Fault Code:...