Detroit Diesel
Detroit DD13 EPA10 (2010-13) Fault Code: SPN 1077 FMI 5 (MCM) Quantity Control Valve Current Too Low
Posted by Diezel Solutions on
DESCRIPTION:Quantity control valve (QCV) error. MONITORED PARAMETER:Quantity control valve. TYPICAL ENABLING CONDITIONS:RP closed loop control. MONITOR SEQUENCE:None EXECUTION FREQUENCY:Current less than 200 mA. TYPICAL DURATION:Two seconds DASH LAMPS:1. MIL2. CEL ENGINE REACTION:Derate 25% VERIFICATION:Engine Idle: One minute. PROBABLE CAUSES:1. Wiring between the ECM and the quantity control valve.2. Quantity control valve. Detroit DD13 EPA10 (2010-13) Fault Code: SPN 1073 FMI 5 (MCM) Jake Brake Stage 2 Circuit Failed Open Detroit DD13 EPA10 (2010-13) Fault Code: SPN 1073 FMI 4 (MCM) Jake Brake Stage 2 Circuit Failed Low Detroit DD13 EPA10 (2010-13) Fault Code: SPN 1073 FMI 3 (MCM) Jake Brake...
Detroit DD13 EPA10 (2010-13) Fault Code: SPN 1077 FMI 7 (MCM) Rail Pressure Deviation is Greater the 200 Bar for Eight Seconds
Posted by Diezel Solutions on
NOTE: The motor control module (MCM) sets the code. POSSIBLE CAUSES:1. External fuel leakage between the high pressure pump and fuel injectors.2. Pressure limiting valve (PLV) leakage (Internal).3. Fuel filter integrity (Loose caps, plugged filters).4. Fuel supply issues (fuel level, fuel aeration, leaking fuel lines, fuel restrictions).5. Intermittent loss of engine speed signal.6. High pressure pump internal failure.7. Fuel injector (amplifier or needle) leakage.8. Fuel contamination.9. Rail pressure sensor.10. MCM. PROBABLE CAUSES:1. External fuel leakage between the high pressure pump and fuel injectors.2. Pressure limiting valve leakage (internal).3. Fuel filter integrity.4. Fuel supply issue.5. Intermittent loss of engine speed signal.6....
Detroit DD13 EPA10 (2010-13) Fault Code: SPN 108 FMI 13 (MCM, CPC, ACM) Ambient Air Pressure Signal Not Available via CAN
Posted by Diezel Solutions on
NOTE: Please see the step by step troubleshooting procedures for this specific code. NOTE: If any engine computer modules have been programmed recently, clear the codes if they are not active. NOTE: Turn key off, disconnect batteries for 5 minutes. Reconnect. If codes still active, refer to code 625-9. Detroit DD13 EPA10 (2010-13) Fault Code: SPN 108 FMI 4 (MCM) Barometric Pressure (BP) Sensor Circuit Failed Low Detroit DD13 EPA10 (2010-13) Fault Code: SPN 108 FMI 3 (MCM) Barometric Pressure (BP) Sensor Circuit Failed High Detroit DD13 EPA10 (2010-13) Fault Code: SPN 107 FMI 0 (CPC) Air Filter Restriction High...
Detroit DD13 EPA10 (2010-13) Fault Code: SPN 108 FMI 3 (MCM) Barometric Pressure (BP) Sensor Circuit Failed High
Posted by Diezel Solutions on
DESCRIPTION:Barometric pressure circuit failed high. MONITORED PARAMETER:Barometric pressure sensor. TYPICAL ENABLING CONDITIONS:Always enabled MONITOR SEQUENCE:None EXECUTION FREQUENCY:Always enabled TYPICAL DURATION:2 seconds DASH LAMPS:1. MIL2. CEL ENGINE REACTION:Derate 25% VERIFICATION:Engine Idle: One minute. NOTE: Replace the MCM (Engine ECM). Detroit DD13 EPA10 (2010-13) Fault Code: SPN 107 FMI 0 (CPC) Air Filter Restriction High Detroit DD13 EPA10 (2010-13) Fault Code: SPN 103 FMI 4 (MCM) Turbo Speed Sensor Failed Low Detroit DD13 EPA10 (2010-13) Fault Code: SPN 103 FMI 1 (MCM) Turbocharger Speed Below Threshold (High Box) Detroit DD13 EPA10 (2010-13) Fault Code: SPN 103 FMI 0 (MCM) Turbocharger Speed Below...
Detroit DD13 EPA10 (2010-13) Fault Code: SPN 108 FMI 4 (MCM) Barometric Pressure (BP) Sensor Circuit Failed Low
Posted by Diezel Solutions on
DESCRIPTION:Barometric pressure circuit failed low. MONITORED PARAMETER:Barometric pressure sensor. TYPICAL ENABLING CONDITIONS:Always enabled MONITOR SEQUENCE:None EXECUTION FREQUENCY:Always enabled TYPICAL DURATION:2 seconds DASH LAMPS:1. MIL2. CEL ENGINE REACTION:Derate 25% VERIFICATION:Engine Idle: One minute. NOTE: The BP sensor is internal to the MCM. NOTE: Replace the MCM (Engine ECM). Detroit DD13 EPA10 (2010-13) Fault Code: SPN 108 FMI 3 (MCM) Barometric Pressure (BP) Sensor Circuit Failed High Detroit DD13 EPA10 (2010-13) Fault Code: SPN 107 FMI 0 (CPC) Air Filter Restriction High Detroit DD13 EPA10 (2010-13) Fault Code: SPN 103 FMI 4 (MCM) Turbo Speed Sensor Failed Low Detroit DD13 EPA10 (2010-13)...